PDA

View Full Version : early 911 alternator test



PNW 73S
06-28-2002, 06:16 PM
Greetings all,

I suspect the Marchal alternator on my '73 911 to be faulty, but I'm not familiar enough with the early 911's charging system to know for sure. On many vehicles, simply disconnecting the negative battery cable with the engine running can indicate a faulty alternator....if the engine dies, the alternator isn't charging.

I tried this on my 911 and the engine does indeed die. Can someone with experience in this area if this is conclusive evidence that the alternator is the problem?

To give a little background on the problem, I washed the car over the weekend and when I went to start it the next day, the electrical system was completely dead. So I jumped started the vehicle and it ran fine for about 5 minutes before it died...the electrical system completely drained again. This occured 3-4 times. Each time the car is jumpstarted, the alternator light comes on. Bright at first, then gradually dimmer...and dimmer...and dimmer, until it goes out and then the engine dies and everything goes dead.

Any thoughts?

Thanx,
Tony

pwd72s
06-29-2002, 08:21 AM
THis link should help : forums.pelicanparts.com/s...adid=72965 (http://forums.pelicanparts.com/showthread.php?s=&threadid=72965)

911SRegistry
06-29-2002, 02:00 PM
With all due respects to the Pelican thread, not entirely correct.

A fully charged battery should be in the neighborhood of 13.2 volts. If it's lower than this, make sure its fully charged before you test the vehicle's electrical system. A load test can confirm the battery is okay.

With accessories ON and car running at around 2000 rpm or so, the charging system should be putting out about 14.5 volts. If not, the charging system is not working correctly (bad alternator, regulator, component connections, ground).

The alternator supplies most of the electricity while the car is running. The battery is there primarily for starting (cranking the engine) and for low idle speeds.

Do not disconnect any battery cable while the engine is running. If your alternator was functioning okay before this, it won't after disconnecting it (unless you feel lucky).

The alternator light indicates the battery is not charging. It should light with the ignition ON (engine OFF) to indicate it's functioning, but should be OFF while the engine is running.

Washing your car and electrical system dieing may be coicidental. Not sure what you washed. I'd suggest charging the battery, perform the above checks, then drive it down to a good automotive electrical shop for a thorough diagnosis. You should be able to pay them to just diagnosis; not repair if you want to DIY.

Hope this helps,
Sherwood Lee

PNW 73S
07-04-2002, 12:46 PM
Hello again,

I thought you might like to know that the SEV Marchal voltage regulator was faulty and responsible for the problems I posted earlier. After swapping it out for a Transpo #ID4010 unit, the car fired right up and is running great. I'd like to find another Marchal regulator for authenticity purposes, does anyone have any suggestions on where I might be able to locate one???

I can only assume that some water managed to seep into the Marchal case and shorted the unit out, but maybe it's just a coincidence.

For those of you in the Seattle area, I highly recommend Romaine Electric if you ever need assistance with your charging system. They were very helpful.

Thanks again for everyone's help, and have an excellent 4th!

Very best,
Tony Curless

pwd72s
07-06-2002, 07:50 AM
Always great to hear of a good ending...